Bobcat S130B Skid Steer Loader Service Manual 6903151-21416B320113.pdf -Bookmark created by https://wimanual.com MAINTENANCE SAFETY ALPHABETICAL INDEX CONTENTS FOREWORD SAFETY INSTRUCTIONS Fire Prevention SERIAL NUMBER LOCATIONS Loader Serial Number Engine Serial Number DELIVERY REPORT LOADER IDENTIFICATION SAFETY AND MAINTENANCE LIFTING AND BLOCKING THE LOADER Procedure LIFT ARM SUPPORT DEVICE Installing Lift Arm Support Device Removing The Lift Arm Support Device OPERATOR CAB Description Raising The Operator Cab Lowering The Operator Cab Emergency Exit TRANSPORTING THE BOBCAT LOADER Procedure TOWING THE LOADER Procedure REMOTE START Procedure SERVICE SCHEDULE Chart AIR CLEANER SERVICE Checking Replacing Filter Element(s) ENGINE COOLING SYSTEM Cleaning The Cooling System Checking The Coolant Level Replacing The Coolant FUEL SYSTEM Fuel Specifications Filling the Fuel Tank Fuel Filter Removing Air From The Fuel System ENGINE LUBRICATION SYSTEM Checking Engine Oil Oil Chart Replacing Oil And Filter HYDRAULIC Checking And Adding Fluid Replacing Hydraulic Replacing Hydrostatic Motor Case Drain Filter(s) Replacing Hydraulic Fluid Breather Cap FINAL DRIVE TRANSMISSION (CHAINCASE) Checking And Adding Oil Removing The Oil FAN GEARBOX Checking And Maintaining BOB-TACH Inspection And Maintenance POWER BOB-TACH Inspection And Maintenance LUBRICATION OF THE BOBCAT LOADER Procedure TIRE MAINTENANCE Wheel Nuts Rotating Mounting SPARK ARRESTOR MUFFLER Servicing HYDRAULIC SYSTEM HYDRAULIC HYDRAULIC SYSTEM INFORMATION Glossary Of Hydraulic Tighten Procedures Troubleshooting Chart CYLINDER (LIFT) Checking Removal And Installation Identification Disassembly Assembly CYLINDER (TILT) Checking Removal And Installation Rod End Pivot Pin Bushing And Seal Replacement Identification Disassembly Assembly CYLINDER (POWER BOB-TACH) Checking Removal And Installation Parts Identification Disassembly Assembly MAIN RELIEF VALVE Checking Adjustment Removal and Installation HYDRAULIC CONTROL VALVE (FOOT CONTROL) Removal And Installation Identification Chart BICS� Valve, Lift Load Check Valve Removal And Installation Load Check Valve Removal And Installation (Tilt & Auxiliary) Anti-Cavitation Valve (Lift, Rod End) Port Relief Port Relief Port Relief Port Relief Valve Plug Removal Rubber Boot Removal and Installation End Cap Lift Spool and Detent Removal and Installation Tilt Spool Removal and Installation Auxiliary Spool Removal And Installation Auxiliary Solenoid Disassembly and Assembly BICS� Valve Solenoid Disassembly And Assembly BICS� Valve, Lock Valve Removal And Installation BICS� Valve, Check Valve Removal And Installation BICS� Valve, Lift Arm By-Pass Orifice Disassembly And Assembly Main Relief Valve HYDRAULIC CONTROL VALVE (ADVANCED CONTROL SYSTEM) (ACS) Removal And Installation Actuator Removal And Installation (Out of Loader) Identification Chart (ACS) BICS� Valve, Lift Load Check Valve Removal And Installation Load Check Valve Removal And Installation (Tilt & Auxiliary) Anti-Cavitation Valve (Lift, Rod End) Port Relief Port Relief Port Relief Port Relief Valve Plug Removal End Cap Block Removal and Installation Lift Spool Removal and Installation Tilt Spool Removal and Installation Auxiliary Spool Removal And Installation Auxiliary Solenoid Disassembly and Assembly BICS� Valve Solenoid Disassembly And Assembly BICS� Valve, Lock Valve Removal And Installation BICS� Valve, Check Valve Removal And Installation BICS� Valve, Lift Arm By-Pass Orifice Disassembly And Assembly Main Relief Valve LIFT ARM BY-PASS CONTROL VALVE Inspecting Removal And Installation Disassembly And Assembly HYDRAULIC PUMP Check The Output Of The Hydraulic Pump Without Rear Auxiliary Check The Output Of The Hydraulic Pump With Rear Auxiliary Removal And Installation Identification Disassembly And Assembly HYDRAULIC Housing Removal And Installation HYDRAULIC FLUID RESERVOIR Removal And Installation BUCKET POSITION VALVE Solenoid Removal And Installation Solenoid Testing Removal And Installation Disassembly And Assembly REAR AUXILIARY DIVERTER VALVE Removal And Installation Disassembly And Assembly POWER BOB-TACH BLOCK Removal And Installation Disassembly And Assembly FRONT AUXILIARY HYDRAULIC COUPLER BLOCK Removal and Installation Disassembly And Assembly HYDROSTATIC SYSTEM HYDROSTATIC SYSTEM INFORMATION Troubleshooting Chart Replenishing Valve Function HYDROSTATIC MOTOR Removal And Installation Parts Identification Disassembly Assembly Carrier Shaft Seal Replacement Carrier Removal And Installation Carrier Parts Identification Carrier Disassembly Carrier Assembly CHARGE PRESSURE Sender Removal And Installation Checking Charge Pressure Adjusting HYDROSTATIC PUMP Replenishing Removal And Installation Parts Identification (Right Half) Parts Identification (Left Half) Hydraulic Pump Removal And Installation Pump Separation Disassembly Assembly DRIVE BELT Shield Removal And Installation Adjusting Drive Belt Replacement Tensioner Pulley Removal And Installation Tensioner Pulley Parts Identification Tensioner Pulley Disassembly Tensioner Pulley Assembly OIL COOLER Removal and Installation DRIVE SYSTEM BRAKE Disc Removal And Installation Switch Operated Parking Brake DRIVE COMPONENTS Axle Seal Removal And Installation Axle Sprocket And Bearings Removal And Installation Chain Removal And Installation CHAINCASE Checking And Adding Oil Removing The Oil Front Cover Removal And Installation Center Cover Removal And Installation Rear Cover Removal And Installation MAIN FRAME SEAT BAR Removal And Installation Assembling Components Compression Spring Disassembly And Assembly OPERATOR CAB Gas Cylinder Removal And Installation Gas Cylinder Disassembly Removal And Installation OPERATOR SEAT Removal And Installation Seat Belt Removal And Installation OPERATOR SEAT (SUSPENSION) Removal And Installation Slide Rail Removal And Installation Cushion Removal And Installation Back Removal And Installation Shock Removal And Installation 3-Point Seat Belt Removal And Installation BOB-TACH Removal And Installation Bob-Tach Lever And Wedge Bob-Tach Stops POWER BOB-TACH Removal And Installation Power Bob-Tach Lever And Wedge LIFT ARM Removal And Installation REAR GRILL Removal And Installation REAR DOOR Removal And Installation Striker Removal and Installation Striker Disassembly and Assembly Door Latch and Catch Adjustment Latch Removal And Installation FUEL TANK Removal And Installation Fuel Level Sender CONTROL PEDALS Removal And Installation Pedal Adjustment Crossbar Linkage Removal And Installation Lift Foot Pedal Linkage Removal And Installation Tilt Foot Pedal Linkage Removal And Installation CONTROL PEDALS (ACS) Foot Sensor Removal And Installation Foot Pedal Removal And Installation Foot Pedal Linkage Disassembly And Assembly CONTROL PANEL Description Removal and Installation Shock Removal And Installation Shaft Removal And Installation Shaft Disassembly And Assembly Linkage Removal And Installation Pintle Arm Disassembly and Assembly Linkage Neutral Adjustment Linkage Travel Adjustment CONTROL HANDLE Control Lever Removal And Installation Control Rubber Boot Replacement CONTROL HANDLE (ADVANCED CONTROL SYSTEM) (ACS) SELECTABLE HAND Components Identification Handle Sensor Removal And Installation Control Handle Removal and Installation Control Handle Disassembly and Assembly Control Lever Removal and Installation Control Lever Boot ELECTRICAL SYSTEM & ANALYSIS ELECTRICAL SCHEMATIC ELECTRICAL SYSTEM INFORMATION Troubleshooting Chart Description Relay Switch Location Fuse Location Solenoid Test BATTERY Removal And Installation Servicing Using A Booster Battery (Jump Starting) ALTERNATOR Adjusting The Alternator Belt Alternator Identification Charging System Check Alternator Voltage Test Low Voltage Test High Voltage Test Removal And Installation Rectifier Continuity (Diode) Test Alternator Regulator Test Disassembly Stator Continuity Test Stator Ground Test Rotor Continuity Test Rotor Ground Test Assembly STARTER Checking Removal And Installation Parts Identification Disassembly and Assembly Inspection And Repair No Load Test INSTRUMENT PANEL Left Panel Right Panel (Standard) (With Key Switch) Right Panel - (Deluxe) (With Keyless Start) Right Panel Setup Display Options (Deluxe) Option and Field Accessory Panels Removal And Installation Front Accessory Panel Removal And Installation LIGHTS Front Removal And Installation Rear Removal And Installation BOBCAT CONTROLLER Identification Chart Removal And Installation DIAGNOSTIC SERVICE CODES Display Number Codes List BICS� SYSTEM Inspecting The BICS� Controller (Engine STOPPED - Key ON) Inspecting Deactivation Of The Auxiliary Hydraulics System (Engine STOPPED - Key ON) Inspecting The Seat Bar Sensor (Engine RUNNING) Inspecting The Traction Lock (Engine RUNNING) Inspecting The Lift Arm By-Pass Control Additional Inspection For Loaders With Advanced Controls System (ACS) or Selectable Joystick Control (SJC) Troubleshooting Chart Troubleshooting Guide SEAT BAR SENSOR Troubleshooting Chart Test Removal And Installation BICS� Circuit Test TRACTION LOCK Troubleshooting Chart Inspecting Solenoid Removal And Installation Guide Removal Guide Installation ADVANCED CONTROL SYSTEM (ACS) SELECTABLE HAND Components Identification Troubleshooting Guide Controller, Connector And Wire Identification ACS Controller Removal And Installation Handle Sensor Connector Switch Handle Removal Switch Handle Installation Actuators Disassembly And Assembly Handle Lock Solenoid Removal And Installation Handle Lock Solenoid Disassembly And Assembly Handle Lock Solenoid Connector Calibration Of The ACS System Switchable Hand Foot Sensor Disassembly And Assembly Foot Sensor Connector Foot Lock Solenoid Removal And Installation Foot Lock Solenoid Connector ELECTRICAL Controls Identification Chart FLYWHEEL RPM SENSOR Adjustment ENGINE SERVICE TROUBLESHOOTING Chart ENGINE SPEED CONTROL Removal And Installation Disassembly MUFFLER Removal And Installation AIR CLEANER Removal And Installation RADIATOR Removal And Installation COOLING FAN Drive Tension Pulley Removal And Installation Gearbox Blower Housing Grill Removal And Installation Blower Disassembly And Assembly Gearbox Parts Identification Gearbox Disassembly Gearbox Assembly Gearbox Checking Backlash ENGINE COMPONENTS AND TESTING Compression Checking Glow Plugs Checking Glow Plugs Removal And Installation Fuel Shut-Off Solenoid, Checking Fuel Shut-Off Solenoid Removal And Installation Fuel Injection Pump Removal And Installation Timing The Injection Pump Fuel Injector Removal And Installation Checking Nozzle Injection Pressure Nozzle Spraying Condition Valve Seat Tightness Valve Clearance Adjustment Valve Timing, Checking ENGINE Removal And Installation Engine Mount Replacement FLYWHEEL AND HOUSING Flywheel Removal And Installation Ring Gear Removal And Installation Housing Removal And Installation RECONDITIONING THE ENGINE Cylinder Head Removal And Installation Cylinder Head Disassembly And Assembly Cylinder Head Servicing Cylinder Head Top Clearance Valve Guide Checking Reconditioning The Valve And Valve Seat Valve Spring Rocker Arm And Shaft Checking Timing Gearcase Cover Removal And Installation Idler Gear And Camshaft Removal And Installation Camshaft Servicing Idler Gear And Shaft Servicing Timing Gears Checking Backlash Fuel Camshaft Removal And Installation Fuel Camshaft Governor Crankshaft Gear Removal And Installation Oil Pump Removal And Installation Oil Pump Service Checking Engine Oil Pressure Valve Tappets Piston And Connecting Rod Removal And Installation Piston And Connecting Rod Servicing Connecting Rod Alignment Crankshaft And Bearings Removal And Installation Crankshaft And Bearings, Servicing Cylinder Bore, Checking Water Pump Removal And Installation Water Pump Disassembly And Assembly HEATER COMPONENTS Identification REGULAR MAINTENANCE Filter Elements Removal And Installation BASIC TROUBLESHOOTING Cleaning The Heater Coil Checking The Electrical System Engine Coolant By-Passing The Heater Valve Heater Valve Not Opening Or Closing SYSTEM TROUBLESHOOTING CHART Blower Motor Does Not Operate Blower motor operators normally, but air flow is insufficient HEATER UNIT Removal And Installation Disassembly And Assembly HEATER COIL Removal And Installation HEATER FAN Removal And Installation Disassembly And Assembly Wire Connector Removal and Installation HEATER VALVE Removal and Installation Disassembly And Assembly SPECIFICATIONS LOADER SPECIFICATIONS (S130) Machine Dimensions Performance Controls Engine Hydraulic System Electrical Drive System Capacities Tires ENGINE SPECIFICATIONS Fuel Injection Nozzles Fuel Injection Pump Cylinder Head Valves Valve Springs Valve Timing Rocker Arms Camshaft Tappet Cylinders Piston Rings Pistons Connecting Rod Oil Pump Crankshaft Timing Gear Thermostat TORQUE SPECIFICATIONS FOR BOLTS Torque For General SAE Bolts Torque For General Metric Bolts Torque For Kubota Metric Bolts HYDRAULIC CONNECTION SPECIFICATIONS O-ring Face Seal Connection Straight Thread O-ring Fitting Tubelines And Hoses Flare Fitting O-ring Flare Fitting Port Seal Fitting HYDRAULIC FLUID SPECIFICATIONS Specifications CONVERSIONS Decimal And Millimeter Equivalents U.S. To Metric Conversion SMR S130-1 . Notice: This is a preview not fully updated, please download the full version at https://wimanual.com